50' PROTECHAIRE DRIVE-THRU TRUCK PAINT BOOTH & BAKE OVEN QUOTE# 75C-574Z

MODEL/TYPE: ‘Wet’ Down Draft - pass thru /typeAGE: New – 1980s

Note: This is a batch type wet paint system designed for large vehicles such as trucks. The vehicl
enters the large down-draft paint booth, is manually spray painted then moves directly into the cur
bake-oven located immediately in-line with the booth where it is cured. A common door is used to se
arate the two chambers – Also included in this system is a second smaller side draft wet paint
ooth and dryer oven

SPECIFICATIONS & DESCRIPTION:

Large Wet Paint Booth & Cure Oven – Drive thru design:Down Draft type operation
Booth Dimensions: 50’L x 18’W x 12’H - Actual door entrance width: 11’ Wide
Equipped with swing out door at entry, roll up door at exit end and entrance end to the cure
Also equipped with 4 pumps, 2 cat-walks, powered hoist system –
Air make-up system rated @ 10000 BTU and equipped with side baffles in the side walls & filters i
ceiling
(4) Fibre Glass Water Treatment tanks (3) 2400 gallon & (1) 1800 gallon
Cure Oven Dimensions: 80’L x 13.5’W x 15-16’HDoor: 10’ W x 12’H
Also equipped with 2 fire hoses – Gas fired convection, Re-circulated hot air type heat –

Operating temperature range: 130 – 180 F

Second Paint Booth & Dryer oven: - Batch type set up
Paint Booth is a Side-Draft type – Dimensions:31’L x 18’W x 12’H
Door Width: 9’W x 12’ H
Dryer-Oven: Drive in type - Dimensions:68’L x 13.5’W x 12’H
Door Dimensions: 10’W x 12’H

Other Equipment included with the System –
Ingersoll Rand Air Compressor and Air Dryer unit – model: P-550
(4) Fibre Glass holding tanks – flow meter, cat-walks, pumps, etc.

ELECTRICS:240/480V 3 Ph 60 Hz

CONDITION:Both units are in very good condition – currently set-up and in place

LOCATION:Indiana Plant, near Indianapolis Photos Available!

RETURN to complete inventory display       RETURN to our home page